欢迎光临济南大黄蜂工程机械有限公司

热门关键词:

  • 移动碎石机租赁
  • 圆锥碎石机租赁
  • 反击破碎机租赁
当前位置: 首页 - 新闻中心 >
山东大黄蜂工程机械有限公司
电    话:18366127778
地    址:济南市槐荫区经一路273号群盛华城2号楼1-404
网    址:http://www.dhfjx.cn
新闻中心
如何提高移动碎石机的生产效率?
网址:http://www.dhfjx.cn    发布时间:2020-08-04
要想保证移动碎石机具有高的生产率、合格的产品、低的动力消耗和稳定的长期运行的重要因素,就是正确的运转和合理的、及时的维护保养。移动碎石机的维护保养工作,主要着重在润滑、紧固、调整和清扫等几方面。
In order to ensure that the mobile stone crusher has high productivity, qualified products, low power consumption and stable long-term operation, the important factor is correct operation and reasonable and timely maintenance. The maintenance of mobile stone crusher mainly focuses on lubrication, fastening, adjustment and cleaning.
破碎机在工作过程中,各摩擦面应及时可靠的润滑,从而确保破碎机的长期正常运行。因此,对各润滑部位的润滑必须特别注意。否则将引起事故,甚大事故。对于复摆式破碎机的动颚轴承和推力板与支承垫同的润滑,一般采用干油润滑。在冬天时,如遇有干油有凝固可能时,可在其中再加入20%的汽车润滑油进行润滑。各接触面的润滑必须全面,均匀。但在滚动轴承座内润滑油的装满程度,不应超过其容积的50—70%。根据运行使用情况,可每1-2天填注油一次,每季度换一次润滑油。同时,对轴承进行彻底清洗后检查。实践证明,能按期填加更换润滑油是能延长轴承等零件的使用寿命。
In the working process of the crusher, each friction surface should be lubricated timely and reliably, so as to ensure the long-term normal operation of the crusher. Therefore, special attention must be paid to the lubrication of each lubricating part. Otherwise, it will cause accidents, very serious accidents. Dry oil lubrication is generally used for the same lubrication of moving jaw bearing, thrust plate and support pad of compound pendulum crusher. In winter, if the dry oil is likely to solidify, 20% automobile lubricating oil can be added to it for lubrication. The lubrication of all contact surfaces must be comprehensive and uniform. However, the filling degree of lubricating oil in the rolling bearing seat should not exceed 50-70% of its volume. According to the operation condition, the oil can be filled every 1-2 days and the lubricating oil should be changed once every quarter. At the same time, check the bearing after thorough cleaning. It has been proved by practice that the service life of bearings and other parts can be prolonged by adding and changing lubricating oil on schedule.
              移动碎石机租赁
移动碎石机的润滑:我们所用的稀油润滑系统一般是由油泵、过滤冷却器,油压调整阀、油箱、油管,仪表指示装置等组成。当油压过高或油流量过大时,可通过油压调整阀来进行调整,正常润滑过程中,油的流量必须适当。稀油润滑系统之回油温度不可高于600度,油箱中正常温度应控制在35~50℃。当油温过高时,应采取水冷却措施,水压应低于油压0.5大气压。在油过滤器前后压力差超过0.40大气压力时,应进行清洗过滤器。稀油润滑的润滑油在正常运行状况下,应每3—6个月进行一次更换,并同时彻底用煤油清洗油箱及其他有关润滑部件,零件,以确保整个润滑系统的畅通无阻,油质清洁。对于定时用人工润滑之部位,更应注意及时、适量、准确的进行润滑。
Lubrication of mobile stone crusher: the thin oil lubrication system we use is generally composed of oil pump, filter cooler, oil pressure regulating valve, oil tank, oil pipe, instrument indicating device, etc. When the oil pressure is too high or the oil flow is too large, it can be adjusted through the oil pressure regulating valve. In the normal lubrication process, the oil flow must be appropriate. The return oil temperature of the thin oil lubrication system should not be higher than 600 ℃, and the normal temperature in the oil tank should be controlled at 35 ~ 50 ℃. When the oil temperature is too high, water cooling measures should be taken, and the water pressure should be 0.5 ATM lower than the oil pressure. When the pressure difference before and after the oil filter exceeds 0.40 atmospheric pressure, the filter should be cleaned. Under normal operation conditions, the lubricating oil lubricated by thin oil should be replaced every 3-6 months, and the oil tank and other related lubricating parts and parts should be cleaned thoroughly with kerosene to ensure the smooth and clean lubrication system. For the parts with regular manual lubrication, more attention should be paid to timely, appropriate and accurate lubrication.
提高移动碎石机的生产率是必须的,但是在提高的时候切记要在保证移动碎石机使用寿命的前提下提高,不能一味的为了提高生产率而损害了机器本身。
It is necessary to improve the productivity of mobile stone crusher, but in the process of improvement, it is important to ensure the service life of mobile stone crusher. It is not allowed to damage the machine itself in order to improve productivity blindly.
以上是关于提高移动碎石机生产率的相关内容介绍,希望对大家有所帮助,想要了解更多内容欢迎点击我们移动碎石机租赁http://www.dhfjx.cn官网。
The above is about improving the productivity of mobile stone crusher, hope to help you, want to learn more, welcome to click on our mobile stone crusher rental http://www.dhfjx.cn Official website.
上一条:颚式移动碎石机在运行时需要注意...        下一条:使用移动碎石机的好处有哪些?

创新驱动发展,科技引领未来,诚信铸就品牌

地址:济南市槐荫区经一路273号群盛华城2号楼1-404  电话:18366127778

山东大黄蜂工程机械有限公司      流量分析: