欢迎光临山东大黄蜂移动碎石机租赁出租公司

热门关键词:

  • 移动碎石机租赁
  • 圆锥碎石机租赁
  • 反击破碎机租赁
当前位置: 首页 - 新闻中心 >
新闻中心
山东大黄蜂工程机械有限公司
电    话:18366127778
地    址:济南市槐荫区经一路273号群盛华城2号楼1-404
网    址:http://www.dhfjx.cn
新闻中心
碎石机容易生锈怎么办?
网址:http://www.dhfjx.cn    发布时间:2020-05-28
  在日常生活中,无论什么产品使用一段时间,都会有磨损和损坏,特别是碎石机等金属材料长期处于恶劣环境中,如果维修不到位就会产生锈蚀。从而降低了设备的生产效率,导致产品达不到用户的要求。那么,生锈的解决方案是什么呢?
  In daily life, no matter what products are used for a period of time, there will be wear and damage, especially the metal materials such as stone crusher are in a bad environment for a long time, if the maintenance is not in place, corrosion will occur. Thus, the production efficiency of the equipment is reduced, resulting in the product can not meet the requirements of users. So what's the solution to rust?
  一,在化学领域,酸是一种通过与金属氧化物发生化学反应,对碎石机金属表面进行除锈的方法。一般来说,除锈都是酸洗,但这只能在车间里进行。
  1、 In the field of chemistry, acid is a method to remove rust on the metal surface of the crusher by chemical reaction with metal oxide. Generally speaking, rust removal is acid pickling, but this can only be carried out in the workshop.
  二,氧化漆。在碎石机的生产过程中,如果发现设备金属表面有掉漆现象,就要及时涂抹防氧化漆。
  2、 Oxide paint. In the production process of the crusher, if the paint on the metal surface of the equipment is found to fall off, the anti-oxidation paint shall be applied in time.
轮胎式破碎机
  三,用高压水除锈。碎石机采用高压水流冲击,雪橇破坏腐蚀和涂层,与钢板粘合无粉尘污染,对钢板无损伤,大大提高了除锈效率。同时,除锈钢板容易生锈,需要涂覆特殊的除锈材料,这对涂料的综合性能影响很大。
  3、 Remove rust with high pressure water. The crusher is impacted by high-pressure water flow, the sled damages the corrosion and coating, and it is bonded with the steel plate without dust pollution and damage to the steel plate, which greatly improves the efficiency of derusting. At the same time, the derusting steel plate is easy to rust and needs to be coated with special derusting materials, which has a great impact on the comprehensive performance of the coating.
  四,电除锈。碎石机可采用电收尘器,主要由电力或压缩空气提供动力,并配有适当的除尘装置进行往复运动,以适应各种场合的除锈要求。
  4、 Electric derusting. The crusher can adopt electric dust collector, which is mainly powered by electric power or compressed air, and equipped with appropriate dust removal device for reciprocating movement, so as to meet the requirements of rust removal in various occasions.
  五,防氧化涂料。碎石机的铁表面涂有矿物油、油漆等,钢铁表面电镀一层不生锈的金属,形成致密的氧化膜,防止生锈与水、空气等物质接触。在破碎机存放或季节性停机期间,破碎机及其拆卸部件应存放在稳定的支架上,以防与地面接触。每月至少运行一次破碎机5分钟,以确保轴承得到适当润滑。
  5、 Anti oxidation coating. The iron surface of the crusher is coated with mineral oil, paint, etc., and the steel surface is electroplated with a layer of stainless metal to form a dense oxide film to prevent the rust from contacting with water, air and other substances. During the storage or seasonal shutdown of the crusher, the crusher and its disassembled parts shall be stored on stable supports to prevent contact with the ground. Run the crusher at least once a month for 5 minutes to ensure that the bearings are properly lubricated.
上一条:破碎机安装时要注意这五条!        下一条:反击碎石机相对于锤式碎石机有哪...

创新驱动发展,科技引领未来,诚信铸就品牌

地址:济南市槐荫区经一路273号群盛华城2号楼1-404  电话:18366127778

山东大黄蜂工程机械有限公司      流量分析: