欢迎光临济南大黄蜂工程机械有限公司

热门关键词:

  • 移动碎石机租赁
  • 圆锥碎石机租赁
  • 反击破碎机租赁
当前位置: 首页 - 新闻中心 >
山东大黄蜂工程机械有限公司
电    话:18366127778
地    址:济南市槐荫区经一路273号群盛华城2号楼1-404
网    址:http://www.dhfjx.cn
新闻中心
移动碎石机启动时的注意事项?
网址:http://www.dhfjx.cn    发布时间:2020-02-27
(1)破碎机启动前,应先启动油泵电机和冷却系统。当油流正常时,应打开环式破碎机的电机。
  (1) Before starting the crusher, start the oil pump motor and cooling system. When the oil flow is normal, open the motor of the ring crusher.
  (2)破碎机启动后,如果出现不正常的敲打声,应在发现病害后停止运行。重新启动机器。破碎机需要无负荷启动,启动一段时间后,经过一段时间后,才可以开始正常运行加料设备,对破碎机物料应逐渐增加,适合满负荷运行。
  (2) After the crusher is started, if there is abnormal knocking sound, it shall stop running after finding the disease. Restart the machine. The crusher needs to be started without load. After starting for a period of time, after a period of time, the normal operation of the feeding equipment can be started. The material of the crusher should be gradually increased, which is suitable for full load operation.
  (3)在操作过程中,注意进料均匀,物料不得填满破碎腔;和喂养的大尺寸不应大于喂口的宽度的0.85倍,与此同时,战斗时破碎的物体,如铁进入破碎机,一旦发现破碎的物体进入破碎腔,并通过机器范,材料应立即通知到下一个“发布时间,以免在下段破碎机,造成严重的设备事故。
  (3) In the process of operation, pay attention to the uniformity of feeding, and the materials shall not fill the crushing chamber; and the large size of feeding shall not be greater than 0.85 times of the width of feeding mouth. At the same time, the broken objects, such as iron, shall enter the crusher when fighting. Once it is found that the broken objects enter the crushing chamber, and pass the machine model, the materials shall be immediately notified to the next "release time, so as to avoid the crusher in the next section, Cause serious equipment accidents.
移动碎石机租赁
  (4)操作过程小,还要注意大料堵住喀什破碎机的进料口,如果被卡住了,一定要用铁钓来翻料;如果需要从粉碎室取出大块材料,应使用专用设备。
  (4) The operation process is small, and attention should be paid to blocking the feeding port of Kashi crusher with large materials. If it is stuck, it must be turned over with iron fishing; if it is necessary to take out large materials from the crushing chamber, special equipment should be used.
  (5)运行中,物料过多或破碎腔堵塞时,应暂停给料,破碎腔内物料破碎后,应启动给料机,但此时不能停止破碎机。
  (5) During operation, when there are too many materials or the crushing chamber is blocked, the feeding shall be suspended. After the materials in the crushing chamber are broken, the feeder shall be started, but the crusher cannot be stopped at this time.
  (6)机器的运行时,应采取定期巡回检查,通过这种方式看到的,听到的,触摸、观察破碎机零件的工作条件和轴承温度,滑动轴承的大型颚式破碎机,更应注意轴承温度、轴承温度不超过60℃,通常为了防止合金轴瓦的融化,产生烧瓦故障。当肖发现轴承的温度非常高,不立即停止机器,但采取有效措施,降低轴承的温度随着时间的推移,比如增加石油供应,强制通风或水冷,等等:停止机器检查和轴承温度下降后故障排除。
  (6) During the operation of the machine, regular patrol inspection shall be carried out. The working conditions and bearing temperature of the parts of the crusher can be seen, heard, touched and observed in this way. For the large jaw crusher with sliding bearing, more attention shall be paid to the bearing temperature and bearing temperature not more than 60 ℃. Generally, in order to prevent the melting of the alloy bearing bush and the bearing burning failure. When Xiao found that the temperature of the bearing was very high, he did not stop the machine immediately, but he took effective measures to reduce the temperature of the bearing over time, such as increasing the oil supply, forced ventilation or water cooling, etc.: stop the machine inspection and troubleshooting after the temperature of the bearing dropped.
  (7)为保证机器的正常运行,不熟悉操作规程的人员不得单独操作破碎机。
  (7) In order to ensure the normal operation of the machine, personnel who are not familiar with the operating procedures shall not operate the crusher alone.
  (8)破碎机停车时,应按顺序停车。目的是先停止进料,待破碎腔内的物料全部排出后再停止破碎机。当破碎机停止时,请停止油泵电机。
  (8) When the crusher is stopped, it shall be stopped in sequence. The purpose is to stop feeding first, and then stop the crusher after all the materials in the crushing chamber are discharged. When the crusher stops, please stop the oil pump motor.
  (9)应注意,破碎机由于某种原因突然停止。当事故结束,破碎机准备启动时,需要清理破碎室内积压的物料,启动破碎机。
  (9) It should be noted that the crusher stops suddenly for some reason. When the accident is over and the crusher is ready to start, it is necessary to clear the overstocked materials in the crushing room and start the crusher.
  以上就是移动碎石机租赁对移动碎石机启动时的注意事项的详细介绍,想要了解更多请点击官网http://www.dhfjx.cn
  The above is a detailed introduction of the precautions for mobile lithotripter leasing when starting up. To learn more, please click http://www.dhfjx.cn
上一条:圆锥碎石机卡机的解决措施都有哪...        下一条:造成反击破碎机的板锤更换的原因...

创新驱动发展,科技引领未来,诚信铸就品牌

地址:济南市槐荫区经一路273号群盛华城2号楼1-404  电话:18366127778

山东大黄蜂工程机械有限公司      流量分析: