欢迎光临济南大黄蜂工程机械有限公司

热门关键词:

  • 移动碎石机租赁
  • 圆锥碎石机租赁
  • 反击破碎机租赁
当前位置: 首页 - 新闻中心 >
山东大黄蜂工程机械有限公司
电    话:18366127778
地    址:济南市槐荫区经一路273号群盛华城2号楼1-404
网    址:http://www.dhfjx.cn
新闻中心
破碎机总是无故停机?这几点需要注意
网址:http://www.dhfjx.cn    发布时间:2019-05-17
破碎机突然停机不仅会造成机器自身的损坏,还会严重影响工作效率。为了避免出现破碎机总是停机的现象,反击破碎机租赁厂家给大家总结了以下的几个注意事项,我们在日常使用的时候要格外注意!
Sudden shutdown of crusher will not only cause damage to the machine itself, but also seriously affect work efficiency. In order to avoid the phenomenon that crusher always stops, the retaliatory crusher rental manufacturer summarizes the following points for attention, we should pay special attention to daily use!
一、避免物料堵塞
I. Avoiding Material Blockage
不同类型的破碎机对于物料的要求也不同,尤其是颚式破碎机,要求物料要均匀投放,切记不可一次性投入太多物料,湿度比较大的物料要事先进行处理后再投放至腔内。同时要注意投入物料的硬度,避免过硬的物料对机器内壁造成损坏,从而出现停机的现象。
Different types of crushers have different requirements for materials, especially jaw crushers, which require materials to be evenly put in. It is important to remember that not too many materials should be put in one time. Material with high humidity should be pre-processed before being put into the cavity. At the same time, attention should be paid to the hardness of the input material, so as to avoid damage to the inner wall of the machine caused by the super-hard material, thus causing the phenomenon of shutdown.
二、机器配件要定期检查
2. Regular inspection of machine parts
反击破碎机租赁
1、检查电压
1. Check Voltage
破碎机对于电压的要求也是比较高的,合适的电压才能带动机器有效的工作。定期检查工作电压,避免出现电压不稳造成机器停机现象。
Crusher for the voltage requirements are relatively high, the appropriate voltage can drive the effective work of the machine. Check the working voltage regularly to avoid the phenomenon of machine shutdown caused by voltage instability.
2、三角皮带
2. Triangular belt
三角皮带的松弛度对机器的运行影响是比较大的,过松的三角皮带无法为机器运行提供足够的力量,太紧的皮带在机器运行中会出现断裂现象。不仅影响机器正常运行,还会对机器的造成一定程度的损坏。定期检查三角皮带,避免出现机器停机和工作效率低下的现象。
The relaxation of the triangular belt has a great influence on the operation of the machine, too loose triangular belt can not provide enough strength for the operation of the machine, too tight belt will break in the operation of the machine. It not only affects the normal operation of the machine, but also causes a certain degree of damage to the machine. Regular inspection of triangular belt to avoid machine shutdown and inefficiency.
3、检查部件
3. Inspection Components
破碎机的任何一个部件松动或者过紧都会造成机器停机现象的出现,尤其是在机器开始工作之前,一定要做好机器部件的检查,避免因为疏忽造成作业事故的现象。
Any part of crusher loose or too tight will cause the phenomenon of machine shutdown, especially before the machine starts to work, we must do a good job of machine parts inspection, to avoid the phenomenon of accidents caused by negligence.
以上的精彩内容由反击破碎机租赁厂家友情提供,更多的精彩内容请继续关注我们:http://www.dhfjx.cn,我们会有更多的精彩内容等你查看!
The above wonderful content is provided by the friendship of retaliatory crusher rental manufacturers. More wonderful content please continue to pay attention to us: http://www.dhfjx.cn, we will have more wonderful content waiting for you to see!
上一条:矿山机械破碎机故障率高怎么办?        下一条:影响破碎机出料产品质量的四大因...

创新驱动发展,科技引领未来,诚信铸就品牌

地址:济南市槐荫区经一路273号群盛华城2号楼1-404  电话:18366127778

CopyRight © 2018. 山东大黄蜂工程机械有限公司 All Rights Reserved.   技术支持: 济南诺商  
备案号:鲁ICP备17031054号-1  流量分析: